Product ID:59210 SPIRAX HEAVY DUTY 80W/90 LUBRICATING
MSDS Date:09/20/1982
FSC:9150
NIIN:01-035-5394
MSDS Number: BGGMJ

SHELL OIL COMPANY

ENVIRONMENTAL AFFAIRS
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461

Info Phone: 713-241-4819

Preparer: JOHN LEPART

Cage: 54527

SHELL OIL COMPANY

HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

PETROLEUM HYDROCARBONS (NOT SPECIFIED)

Fraction By Weight: 93%

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

ADDITIVES

Fraction By Weight: 6%

POLYMETHACRYLATE

Fraction By Weight: 1%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MANUFACTURER STATES,"LUBE OILS ARE
CONSIDERED TO BE A LOW ORDER ACUTE TOXICITY". IT CONTAINS NO KNOWN
CARCINOGENS OT MUTAGENS AS DEFINED BY OSHA OR IARC." PRODUCT IS
VERY MILDLY IRRITATING TO BODY T ISSUES. MOST LIKELY HAZARD IS
THAT OF BREATHING THE MIST OR VAPORS SHOULD THE PRODUCT BE HEATED
OR MISTED.
Explanation of Carcinogenicity:THE PRODUCT MAY CONTAIN SOME POLYCYCLIC
AROMATIC COMPOUNDS WHICH HAVE BEEN SHOWN TO CAUSE CANCER IN
ANIMALS.
Effects of Overexposure:EYE:MILD IRRITATION. SKIN:POSSIBLE MILD
IRRITATION. INHALED:RESPIRATORY IRRITATION,POSSIBLE PULMONARY EDEMA
IF MIST IS INHALED. INGESTED:NONE GIVEN BY MANUFACTURER
(SUPPLIER).
Medical Cond Aggravated by Exposure:NONE REPORTED

First Aid:EYE:FLUSH W/WATER 15 MIN, HOLD LIDS OPEN. SKIN:WASH WITH
SOAP & WATER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE. INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING IF
NECESSARY. INGESTED:D O NOT INDUCE VOMITING. EMISIS IS NOT USUALLY
NECESSARY UNLESS A LARGE QUANTITY IS INGESTED. GET MEDICAL
ATTENTION. IF IRRITATION PERSISTS OR IS SEVERE,SEE A DOCTOR.

Flash Point Method:PMCC
Flash Point:290F,143C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG. WATER, ESPECIALLY STREAM, MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:OIL MAY FLOAT ON WATER, THEN RE-IGNITE
SPREADING FIRE. DECOMPOSITION AT FIRE TEMPERATURES MAY PRODUCE
TOXIC DECOMPOSITION PRODUCTS.

Spill Release Procedures:RECOVER AS LIQUID IF POSSIBLE. ADSORB
REMAINDER ON EARTH,SAND,SAWDUST,ETC. KEEP OUT OF DRAINS, SEWERS,
AND WATERWAYS. STORE IN CLOSED CONTAINERS PENDING DISPOSAL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN COOL,DRY,WELL VENTILATED
AREA. KEEP AWAY FROM IGNITION SOURCES.
Other Precautions:NONE

Respiratory Protection:RESPIRATOR WILL NOT NORMALLY BE NECESSARY. USE
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR OR RESPIRATOR FOR OIL
MIST IF EXPOSURE IS ABOVE THE TLV/PEL. SEE 29 CFR 1910.134 FOR
REGULATIONS PERTAINING TO RESPIRATOR USE.
Ventilation:NORMAL ROOM VENTILATION SHOULD BE SUFFICIENT. SUPPLEMENT
WITH LOCAL EXHAUST IF NEEDED (OIL MIST).
Protective Gloves:NEOPRENE OR BUTYL RUBBER (OIL RESISTANT)
Eye Protection:SAFETY GLASSES OR SPLASH GOGGLES S
Other Protective Equipment:AS NEEDED TO PREVENT PROLONGED/REPEATED
CONTACT.
Work Hygienic Practices:USE GOOD INDUSTRIAL HYGIENE PRACTICE. MINIMIZE
PERSONAL CONTACT. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MSDS NUMBER 864,020. MSDS SUPPLIED BY NAVY. APPARENTLY OBTAINED FROM
OCTAGON. MSDS DATE HAD BEEN "DOCTORED" TO 20SEP85. IT APPEARED TO
HAVE BEEN 28SEP82.

HCC:V6
Spec Gravity:0.90
pH:NONE
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK AMBER OIL, SLIGHT ODOR
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION - AND MIST FORMATION.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE

Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE, LOCAL REGULATIONS.
DGSC-SSH SUGGESTS RECYCLE OR IF THAT IS NOT PRACTICLE TO
INCINERATE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.